MMMM.. BRISKET..
The BBQ BRETHREN FORUMS.  



Our Homepage Donation to Forum Overhead Welocme Merchandise Associations Purchase Subscription Amazon Affiliate
Go Back   The BBQ BRETHREN FORUMS. > Discussion Area > Q-talk

Notices

Q-talk *ON TOPIC ONLY* QUALITY ON TOPIC discussion of Backyard BBQ, grilling, equipment and outdoor cookin' . ** Other cooking techniques are welcomed for when your cookin' in the kitchen. Post your hints, tips, tricks & techniques, success, failures, but stay on topic and watch for that hijacking.


Reply
 
Thread Tools
Old 03-02-2018, 05:48 PM   #1
cfrazier77
is One Chatty Farker
 
Join Date: 12-26-15
Location: Denver, PA
Name/Nickname : Craig
Default Canning BBQ Sauce

Question for the wealth of information here. I bought a gallon of Blues Hog sauce and want to break it up into smaller amounts for storage. I was thinking of using pint mason jars. What would be the best way to do this, break it down? And if in mason jars should I just do a boil or use the pressure cooker? I don't want to change the flavor but also want it to be shelf stable for up to 6 months.

Thanks!!!
__________________
Humphrey's Down East Beast, Shirley 24 x 60, Weber 22 Kettle, Weber Genesis Gasser
cfrazier77 is offline   Reply With Quote




Old 03-02-2018, 06:05 PM   #2
Joshw
Babbling Farker
 
Join Date: 09-25-17
Location: Oklahoma
Default

It really depends on the acidity of the sauce. Without knowing that, it is hard to say if cold packing is safe. Here is an old link where IamMadman said he cold packed it, and from reading his posts, I would trust him on food safety.

https://www.bbq-brethren.com/forum/s...d.php?t=189882
Joshw is offline   Reply With Quote


Thanks from:--->
Old 03-02-2018, 06:09 PM   #3
Cook
Babbling Farker
 
Join Date: 12-23-10
Location: Mount Pleasant, SC & Harkers Island, NC
Name/Nickname : Jay
Default

If "I" were to do this...

I would sterilize my jars by placing them upright in a pot, fill the pot with hot water until about an inch or so above the top of the jars. Bring to a boil and boil for 10 minutes or more (this will depend on your altitude. Google is your friend here). Along with the jars, drop a pair of tongs, tong down, into the boiling water so they are sterilized also. Turn off the heat & carefully remove the jars with the tongs...it isn't easy emptying the hot water out of them with tongs so go very SLOW!!! Place empty jars upright on a sheet pan in a 200 degree oven (jars should be hot when the liquid is added). Once the jars are out of the pot, drop in the lids & rings. You do not want to boil these so be sure the water has cooled to below the boil. Let them sit in the water for 5-10 minutes.

While all this is happening you should have a pot on the range with your sauce. You probably don't want to boil it, but get it hot...very hot. If it bubbles, immediately reduce the heat, put a lid on it, and keep it HOT.

When the sauce is ready (hopefully it was ready as you were getting the jars sterilized), retrieve the lids & rings from the water pot, and gingerly remove the jars from the oven. Pour sauce into jars, place lids on top, and screw on rings. Let cool and you'll hear the lids pop as they vacuum themselves down.

You could pressure can, but really you don't have to. If everything is hot, they'll be fine...it's barbecue sauce which is typically a safe food anyway.
__________________
"Barbecue...it's just heat & meat" - Circa 5/10/11 - Quote by Cook
Cook is offline   Reply With Quote


Thanks from:--->
Old 03-02-2018, 06:16 PM   #4
BillN
somebody shut me the fark up.

 
Join Date: 03-14-16
Location: St David, Az.
Name/Nickname : Bill
Default

The quickest and fastest way would be to freeze the sauce in ice cube trays, then take out of freezer as needed and let defrost in refrigerator.
__________________
Bill, from Cochise County Arizona
LSG 24 X 36 Horizonatal Offset w/warming oven,
32" fire pit with swinging cooking grate,
PK 360 w/Grill Grates
BillN is offline   Reply With Quote


Thanks from: --->
Old 03-02-2018, 07:25 PM   #5
chilidog
Full Fledged Farker
 
Join Date: 08-07-12
Location: Canyon, Tx
Default

I run my jars through the dishwasher with a cup or so of bleach then can them in a hot water bath- boiling water for 20 minutes.
chilidog is offline   Reply With Quote


Thanks from:--->
Old 03-02-2018, 08:38 PM   #6
cfrazier77
is One Chatty Farker
 
Join Date: 12-26-15
Location: Denver, PA
Name/Nickname : Craig
Default

Thanks all, I am going to do a water bath.
__________________
Humphrey's Down East Beast, Shirley 24 x 60, Weber 22 Kettle, Weber Genesis Gasser
cfrazier77 is offline   Reply With Quote


Old 03-02-2018, 09:39 PM   #7
cowgirl
somebody shut me the fark up.

 
cowgirl's Avatar
 
Join Date: 07-18-07
Location: Oklahoma
Name/Nickname : jeanie
Default

I pressure can it. Not knowing the level of acid in the sauces I make, I go on the safe side. It depends on your ingredients. Peppers and onions can bring the acidity level down.... and I don't add extra vinegar to offset them.
__________________
jeanie
Lifetime member of the Society for the Preservation of Authentic Royal Magical Rare Kaskaskian Peppers (Thanks Ash :))
RIP Ash, you are missed

http://cowgirlscountry.blogspot.com/
cowgirl is offline   Reply With Quote


Thanks from: --->
Old 03-02-2018, 10:44 PM   #8
Hoss
Quintessential Chatty Farker
 
Join Date: 12-31-09
Location: Hernando,MS
Default

Freeze it.
Hoss is offline   Reply With Quote


Thanks from:--->
Old 03-03-2018, 07:14 AM   #9
OSD
is One Chatty Farker
 
OSD's Avatar
 
Join Date: 12-22-05
Location: Pinellas Park, Fl.
Default

I'm guessing from your question that you don't do a lot of canning or you would have a PH meter or strips to test the acidity of the sauce and know if you can water bath the sauce or you need to pressure can the sauce.

So, because it's a commercially made sauce and not homemade and the acidity is unknown, I would freeze it or pressure can it to be on the safe side.

JMHO-YMMV
__________________
Jim
OSD is offline   Reply With Quote


Thanks from:--->
Old 03-03-2018, 08:19 AM   #10
IamMadMan
somebody shut me the fark up.

 
IamMadMan's Avatar
 
Join Date: 07-30-11
Location: Pemberton, New Jersey
Default

I agree with the above; Start with sterilized jars, lids and rings.

Keep in mind that it is a commercial sauce in a plastic jug without a hermetic seal, and it has a two year shelf life so it may have some type of preservative in it, even though it's not listed on the ingredients. At the very least it's pasteurized, put into a sterile jug, and then gently cooled in a water bath during the conveyor ride to the labeling/boxing area.

I worked in the spice/flavoring room for a large food processor, who also made bbq sauce, they added sodium salt of benzoic acid (sodium benzoate) in the "secret" spice blend so they didn't have to list it on the label. They did this to give the appearance of "no preservatives". Not saying if this is the case here, but large commercial producers desire maximum shelf life to maximize total product sales.

If it's in there, you will also be taking advantage of the preservative properties of the sauce. Personally, I do a hot water bath for any blended sauce I make that I plan using in the next six months. I also put the canned jars of sauce in the refrigerator in the garage (I know I don't need to). If I were planning to keep the sauce for much longer, I would probably pressure can the jars as Jeanie has recommended in her post. Sometimes if you have a small amount of jars, it's just easier to use the small pressure canner, than to deal with a big pot for the water bath.

An ounce of prevention is worth a pound of cure.......

.

Last edited by IamMadMan; 03-03-2018 at 08:36 AM..
IamMadMan is online now   Reply With Quote


Thanks from: --->
Old 03-03-2018, 08:32 AM   #11
cfrazier77
is One Chatty Farker
 
Join Date: 12-26-15
Location: Denver, PA
Name/Nickname : Craig
Default

Do you think that raising the temp of the sauce to pressure canning temps, 250, would change the flavor? I do have a pressure canner and and have used it a lot.
__________________
Humphrey's Down East Beast, Shirley 24 x 60, Weber 22 Kettle, Weber Genesis Gasser
cfrazier77 is offline   Reply With Quote


Old 03-03-2018, 09:08 AM   #12
IamMadMan
somebody shut me the fark up.

 
IamMadMan's Avatar
 
Join Date: 07-30-11
Location: Pemberton, New Jersey
Default

Craig,

As I stated, I blend 3 different commercial sauces to make the flavor of sauce I like. In the fall I only make about 6 jars for the winter gatherings so it is easier to put them in the small pressure cooker. I have not noticed any flavor changes.
IamMadMan is online now   Reply With Quote


Thanks from: --->
Old 03-03-2018, 09:48 AM   #13
thirdeye
somebody shut me the fark up.

 
thirdeye's Avatar
 
Join Date: 01-14-06
Location: At home on the range in Wyoming
Default

One more option.... use "straight sided" Mason jars and freeze your sauce in them. Jars with shoulders are not recommended for freezing. Most jars will have a freeze line on the jar but it's usually just below the lowest thread. This way, when you want a jar of sauce just defrost and now you have a container that can live in the fridge until you use it. HERE is a good article on freezing in canning jars. Oh, and buy a canning funnel, it has a stubby but wide outlet and is used for filling jars and reducing the mess factor.
__________________
~thirdeye~

Barbecuist ~ Charcuterist ~ KCBS Master Judge & CTC
Big Green Eggs, Big Drum Smokers, Big Chiefs, Weber Smokey Joe "Custom Tall Boy"
Oil Patch Horizontal, SnS Deluxe Kettle

Visit my Cookin' Site by clicking HERE
Barbecue is not rocket surgery
“The problem with quotes on the Internet is that it's hard to verify their authenticity” ~ Abraham Lincoln
thirdeye is offline   Reply With Quote


Thanks from:--->
Old 03-03-2018, 01:42 PM   #14
cfrazier77
is One Chatty Farker
 
Join Date: 12-26-15
Location: Denver, PA
Name/Nickname : Craig
Default

Quote:
Originally Posted by IamMadMan View Post
Craig,

As I stated, I blend 3 different commercial sauces to make the flavor of sauce I like. In the fall I only make about 6 jars for the winter gatherings so it is easier to put them in the small pressure cooker. I have not noticed any flavor changes.
If you cannot tell a difference then I know that I can't! Thanks!
__________________
Humphrey's Down East Beast, Shirley 24 x 60, Weber 22 Kettle, Weber Genesis Gasser
cfrazier77 is offline   Reply With Quote


Old 03-08-2018, 08:40 PM   #15
cfrazier77
is One Chatty Farker
 
Join Date: 12-26-15
Location: Denver, PA
Name/Nickname : Craig
Default

Thank you Bob and everyone, I pressure canned the sauce at 15 psi for 15 minutes. It worked and no change in flavor. It is a great way to save money by buying by the gallon. Thanks!
__________________
Humphrey's Down East Beast, Shirley 24 x 60, Weber 22 Kettle, Weber Genesis Gasser
cfrazier77 is offline   Reply With Quote


Thanks from: --->
Reply

Thread Tools

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


Forum Custom Search: Enter your Search text below. GOOGLE will search ONLY the BBQ Brethren Forum.
Custom search MAY not work(no display box) in some configurations of Internet Explorer. Please use compliant version of Firefox or Chrome.







All times are GMT -5. The time now is 07:05 AM.


Powered by vBulletin® Version 3.8.8
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
2003 -2012 © BBQ-Brethren Inc. All rights reserved. All Content and Flaming Pig Logo are registered and protected under U.S and International Copyright and Trademarks. Content Within this Website Is Property of BBQ Brethren Inc. Reproduction or alteration is strictly prohibited.
no new posts