The BBQ BRETHREN FORUMS.


Forum Portal Recipes Smoke Signals Magazine Welocme Merchandise Associations Purchase Subscription Brethren Banners
Go Back   The BBQ BRETHREN FORUMS. > Discussion Area > Q-talk

Notices

Q-talk *ON TOPIC ONLY* QUALITY ON TOPIC discussion of Backyard BBQ, grilling, Equipment and just outdoor cookin' in general, hints, tips, tricks & techniques, success, failures... but stay on topic. And watch for that hijacking.


Reply
Thread Tools
Unread 04-28-2013, 12:47 AM   #1
mattdean1003
On the road to being a farker
 
Join Date: 02-27-12
Location: Bogart, GA
Downloads: 0
Uploads: 0
Default Offset smoker is "Grilling" my food

I can't figure out what's going wrong here guys. I'll post pictures of my smoker asap, but it's the Old Country Pits "Ranch Hand" that you can get at Academy Sports for 299. Big, steel welded offset smoker. Anyhow, the grate is expanded metal and on both long cooks I've done on it, temps well under 300 (225 to 275 varying), the bottom of the meat has been completely brittle and dry while the rest of the meat was fine. On my UDS, I've never had that problem. Meat is on the smokestack end of the cook chamber, which is mounted at grate level. Smoker does have deflector welded in it.

Don't get me wrong, the food is great, but that's about a pound and a half of meat I end up having to throw away because you literally have to break it apart. I cooked a pork butt earlier and foiled it at the 10 hour mark, then just stuck it in the oven to rest, and I peeled the entire bottom layer off the meat (which was the fat cap, but fat cap was beyond cooked away)
mattdean1003 is offline   Reply With Quote


Unread 04-28-2013, 12:50 AM   #2
J'ville Grill
is Blowin Smoke!

 
Join Date: 11-18-10
Location: USA
Downloads: 0
Uploads: 0
Default

Where and how are you measuring our pit temps?
__________________
Rick
J'ville Grill is offline   Reply With Quote


Unread 04-28-2013, 12:53 AM   #3
mattdean1003
On the road to being a farker
 
Join Date: 02-27-12
Location: Bogart, GA
Downloads: 0
Uploads: 0
Default

Measuring temp by 2 thermometers that I put in the smoker, both Old Country Pits. One is mounted in center of lid where there was a predrilled hole, the other is mounted on the right hand side about grate level. The top therm usually reads about 25 degrees lower than the bottom therm, which is nearest the firebox.
mattdean1003 is offline   Reply With Quote


Unread 04-28-2013, 06:51 AM   #4
BBQ Bandit
Babbling Farker

 
BBQ Bandit's Avatar
 
Join Date: 02-15-08
Location: Harrisburg, PA
Downloads: 1
Uploads: 0
Default

Sounds like a hotspot. A small offset will have a significant hotspot - requiring a larger baffle between the firebox and smoke chamber.
Even on my big Lang... will run very hot - because the firebox is partially notched into the smoke chamber.
The first foot nearest to the firebox... is my chicken chamber.

Suggest running a biscuit test and verify your temperature range shown in this thread.
http://www.bbq-brethren.com/forum/sh...d.php?t=120485
__________________
Cooking at Mason-Dixon BBQ Services
Lang 84 Deluxe Kitchen known as "The Glamazon" , Custom Klose Backyard Chef... of Snot, and a 22.5 WSM

Former smokers;
Lang 60 Mobile - The Damsel II, Lang 48 Patio - The Damsel, Bubba Keg Grill - RIP, Double Barrel Smoker and a BSKD
BBQ Bandit is offline   Reply With Quote


Unread 04-28-2013, 09:30 AM   #5
J-Rod
is One Chatty Farker
 
J-Rod's Avatar
 
Join Date: 08-15-12
Location: Irish Hills, MI
Downloads: 0
Uploads: 0
Default

Try a "temp zone test". Buy some pork sausages and place them in various areas of your cook chamber and smoke away. The different ways they cook will give a good indication of the warmer and cooler areas, then you can choose accordingly when cooking different meats.
__________________
UDS'-55&16, Akorn, Bar-B-Q Kettle, Drum Grill, miniWSM, cobweb-covered gasser. I'm JD.
J-Rod is offline   Reply With Quote


Unread 04-28-2013, 09:52 AM   #6
Bludawg
Quintessential Chatty Farker
 
Bludawg's Avatar
 
Join Date: 07-04-09
Location: Jonesboro,Tx
Downloads: 0
Uploads: 0
Default

I remember an Aaron Franklin Video where he was cooking a brisket on that same pit. He mentioned that there was a Hot spot on the stack end.
A quick fix is to use the rack from an oven broiler pan under the grate slide it end to end until you find the stack ends temp drop and equalizes across the grate Start it at the stack end and slowly move it toward the FB. Small moves make big changes this is where a few Cans of whomp biscuits come in handy. The factory located thermo port is in the wrong place on that pit as well it is to high to do you any good. KNOW the Temp at GRATE LEVEL that is where your cooking at.
__________________
I never met a Cow that I didn't like with a little Salt & Pepper! Certified PORK-A-HOLIC
Bludawg is offline   Reply With Quote


Thanks from:--->
Unread 04-28-2013, 10:06 AM   #7
grantw
Full Fledged Farker
 
Join Date: 09-13-12
Location: canada
Downloads: 3
Uploads: 0
Default

i have a pellet grill that does the same thing, you have to tame the fire way back and go with the grate temp, you can just use white bread placed all over the grill as a test too. the end my fire box is on is cold and the opposite end is nuclear. if you dont have a decent digital oven temp, then just grab some el cheapos that go right inside the pit. also i find you have to turn the meat as you go as well
grantw is offline   Reply With Quote


Reply

Thread Tools

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Loading



All times are GMT -5. The time now is 03:34 AM.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2014, vBulletin Solutions, Inc.
vBulletin Optimisation provided by vB Optimise v2.6.0 Beta 4 (Lite) - vBulletin Mods & Addons Copyright © 2014 DragonByte Technologies Ltd.
2003 -2012 © BBQ-Brethren Inc. All rights reserved. All Content and Flaming Pig Logo are registered and protected under U.S and International Copyright and Trademarks. Content Within this Website Is Property of BBQ Brethren Inc. Reproduction or alteration is strictly prohibited.
no new posts