|
Q-talk *ON TOPIC ONLY* QUALITY ON TOPIC discussion of Backyard BBQ, grilling, equipment and outdoor cookin' . ** Other cooking techniques are welcomed for when your cookin' in the kitchen. Post your hints, tips, tricks & techniques, success, failures, but stay on topic and watch for that hijacking. |
|
Thread Tools |
03-23-2013, 12:46 PM | #1 |
is One Chatty Farker
Join Date: 08-15-12
Location: Irish Hills, MI
|
Question for you stickburning offset dudes
Hey Brethren- I built an offset a couple years ago out of a 55 gallon drum and used half of a 16 gallon drum for the firebox. Since my UDS and Akorn have all my cooking needs covered, I really never used the offset. I decided to give it a go yesterday as I had some oak and some meat and wanted to play with fire. I started a handful of charcoal, then added the oak to get things going. Yes this thing is leaky as hell and homemade, but I put a layer of firebrick in there under the cook grate(where the baffle/tuning plates would be) and surprisingly it held temp pretty well yesterday while doing the baby backs. Also ran a small water pan.
Here was the problem- SOOT! I was getting a nasty layer of soot all over inside the cooking chamber and of course the FOOD! Not that chunky stuff that falls off the walls from moisture(I've had that happen too) but this was a flat black color soot, like the soot you find on the chimney of an oil lamp or lid of a candle in a jar. Again, I was burning straight oak, and the smoke I was getting out the exhaust was not to my liking either-not thin blue but more blue/grey and cloudy. I know the fire was burning hot and had a good bed of coals to start the next piece of wood added... what do you think it could be? Bad wood? Poor airflow? Both? Thanks for any insights.
__________________
Okie Joe offset, UDS, Akorn, Weber Kettles, I'm JD. |
|
03-23-2013, 01:26 PM | #2 |
is one Smokin' Farker
Join Date: 07-02-10
Location: lake grove, new york
|
Do you have a pic of your smoker? That may help with an opinion.
|
|
03-23-2013, 01:33 PM | #3 |
is one Smokin' Farker
Join Date: 03-19-12
Location: Louisville,Ky
|
Was your wood green?
|
|
03-23-2013, 01:57 PM | #4 |
Banned
Join Date: 02-07-11
Location: brenham, texas
|
That was my first guess also. Also are you runnin enough air and exhaust to have a clean natural burning fire. Stick burners control the heat mostly with the fuel and coals. Once you choke it down in the pursuit of stable temps, this will happen every time.
|
|
03-23-2013, 02:04 PM | #5 |
Babbling Farker
Join Date: 02-15-08
Location: Harrisburg, PA
|
A clean burning fire does not leave soot.
Sounds like a smoldering fire. How was the condition of the wood? What type of wood? Was it dried and seasoned? Moldy or funky wood surface? Green (wet) wood?
__________________
Custom Klose Backyard Chef... of Snot, and a 22.5 WSM Former smokers; Lang 84 Deluxe kitchen, Lang 60 Mobile - The Damsel II, Lang 48 Patio - The Damsel, Bubba Keg Grill - RIP, Double Barrel Smoker and a BSKD |
|
Thanks from:---> |
03-23-2013, 02:36 PM | #6 |
On the road to being a farker
Join Date: 03-15-13
Location: iowa
|
Might be a dumb question but you said u haven't used it in a few years, was the inside of the smoker ckean when you started cooking?
|
|
03-23-2013, 03:48 PM | #7 |
somebody shut me the fark up.
Join Date: 07-04-09
Location: Jonesboro,Tx
|
Green wood or Pine, Poorly designed smoker(either to small exhaust or intake) you said it's leaky so I would go with not enough exhaust choking the fire from smoke backing up and pushing the O2 away from the fire or the wood type or green
__________________
I'm a Proxy Vegetarian> Cows eat grass & I eat cows. |
|
03-23-2013, 03:59 PM | #8 |
Babbling Farker
Join Date: 07-11-11
Location: Tuscaloosa Alabama
|
Above are all good answers, my thinking is intake and exhaust problems. I have cooked with a hint of green hickory added to my fire and never had aproblem, but your wood could be an issue too. Just start narrowing it down, you will come to a conclusion I am sure
|
|
03-23-2013, 04:45 PM | #10 |
On the road to being a farker
Join Date: 06-19-12
Location: Houston, Texas
|
All of the advice here is true. Soot is formed by inadequate or incomplete combustion. That can be caused by many variables, most of the biggies have been mentioned here. You must figure how how to get the temps you need in the meat side of the offset, while ensuring your fire is burning well and getting good combustion air to it.
|
|
Thanks from:---> |
03-23-2013, 04:59 PM | #11 |
Quintessential Chatty Farker
Join Date: 08-01-12
Location: Fairfield, Florida
Name/Nickname : Dave
|
__________________
I'm Dave Got a bunch of cooking toys and a custom metal fabrication shop where I spend my time building all sorts of smokers & outdoor cooking gear. |
|
03-24-2013, 10:16 AM | #12 |
is One Chatty Farker
Join Date: 08-15-12
Location: Irish Hills, MI
|
Thanks for all the replies. As for the condition of the wood, it was seasoned not green, but had been sitting for a while in my wood pile covered with a tarp. felt dry when I handled it, but could've had moisture inside... I don't know really. Next time I'll use fresh seasoned wood not stuff that's been sitting for a couple years and see how that does. As for the intake/exhaust issue, I'm really thinking there's not enough exhaust area to create enough flow. I even drilled a couple 2-1/2" holes at great level opposite the firebox to help. I took some photos but waiting for them to load because yahoo mail sucks LOL. I'll post pics when I can. Thanks again.
__________________
Okie Joe offset, UDS, Akorn, Weber Kettles, I'm JD. |
|
03-24-2013, 10:29 AM | #13 |
is one Smokin' Farker
Join Date: 05-11-10
Location: Doraville GA
|
A small hot fire
for this equals this Is the horse dead yet?
__________________
Super fast Purple Thermapen Shirley Fabrication Offset 24x60, Weber SS Performer date code EE, Weber 18 and 22.5 OTS Kettle w/Marty's handles, Smokey Joe Silver w/wooden handle a.k.a. Mini Me, Weber Smokey Joe Platinum date code ER Sipsey: Secret's in the sauce. |
|
|
|