ブタ
The BBQ BRETHREN FORUMS.


Forum Portal Recipes Smoke Signals Magazine Welocme Merchandise Associations Purchase Subscription Brethren Banners
Go Back   The BBQ BRETHREN FORUMS. > Discussion Area > Q-talk

Notices

Q-talk *ON TOPIC ONLY* QUALITY ON TOPIC discussion of Backyard BBQ, grilling, Equipment and just outdoor cookin' in general, hints, tips, tricks & techniques, success, failures... but stay on topic. And watch for that hijacking.


Reply
Thread Tools
Unread 04-30-2013, 07:54 PM   #1
Arristillius
Got Wood.
 
Arristillius's Avatar
 
Join Date: 06-03-11
Location: Vancouver Wa
Downloads: 0
Uploads: 0
Default New BPS Build First Real Cook

I have been lurking on this board for quite some time, and have quite enjoyed all of the lovely bbq pr0n so I figured I would see what you guys thought of my work, *I realize my camera leaves an annoying blue tint *

I thought about building a UDS for a while but my wife thought the big pappa smoker kit would save me time and effort and result in a much more attractive result, and she normally hates when I spend money, so I couldn't say no

I found a 55 gallon drum used for lemon juice concentrate on craigslist and burned it out with a weed burner, after the initial joy of owning a flamethrower wore off, and my wife begged me to stop burning things in my yard, it only took about an hour to strip the paint, then I scrubbed it out with some simple green and a scotch pad, till it was shiny, rinsed it well, dried it out with the flamethrower for fun, and painted it while it was still warm :P

and the lid :P


for future reference I noted that I should have drilled the holes prior to painting it flat black... it was a bit harder to mark the barrel than I would have liked after the black paint. so it took me a whole day to assemble the kit, and I didn't take any progress pics till I had her oiled up and burning on my patio.


*note the Maverick 732 hanging out, I need to figure out a good solution for the probe cables*
it ran for 13 hours on the first run without me touching it... aside from lunch, I couldn't resist putting some chicken breast in it, made a great sammy

Tonight is the first real cook after two impressive in my opinion dry runs where it stayed within 5 degrees of where I put it for at least 10 hours. I am doing 3 racks of baby back ribs from Costco, and 3 fatty's, because I have never smoked a fatty before *It took me a while to figure out what you guys were talking about* I am just doing them plain out of the package with some rub on them, I might stuff them next time

anyhow here she is loaded up, ill post pics of the results when I pull them, if I remember before I start eating


and here is the smoker all loaded up with what I think is the right color smoke, it looks blue to me
Arristillius is offline   Reply With Quote


Thanks from:--->
Unread 04-30-2013, 08:34 PM   #2
peaspurple
is one Smokin' Farker
 
Join Date: 01-26-09
Location: Georgia transplant in odenton, md
Downloads: 0
Uploads: 0
Default

Very pretty, I am sure you will be happy with it.
__________________
A Wonderful Family!!!
peaspurple is offline   Reply With Quote


Unread 04-30-2013, 08:36 PM   #3
landarc
somebody shut me the fark up.

 
landarc's Avatar
 
Join Date: 06-26-09
Location: San Leandro, CA
Downloads: 0
Uploads: 0
Default

Looking good, Big Poppa makes a nice kit, I envy that bottom vent setup.
__________________
Whip It Off, Chambers!

"perhaps...but then again...maybe not..."
landarc is online now   Reply With Quote


Unread 04-30-2013, 08:40 PM   #4
Carbon
is One Chatty Farker
 
Join Date: 08-24-08
Location: Los Angeles
Downloads: 0
Uploads: 0
Default

Very nice build! I see your kettle is chained.
__________________
....UDS....Mini-WSM....Midi-WSM....Mod-ECB....22.5-OTG....34"wood fired pizza oven....
Carbon is online now   Reply With Quote


Unread 04-30-2013, 08:43 PM   #5
superlazy
is One Chatty Farker

 
superlazy's Avatar
 
Join Date: 04-16-12
Location: Trevor,wi
Downloads: 0
Uploads: 0
Default

Quote:
my wife begged me to stop burning things in my yard,



Nice job, Looks good to me
__________________
18.5 WSM, Weber genesis,little pig grill,crappy smokin pit pro
superlazy is offline   Reply With Quote


Unread 04-30-2013, 08:49 PM   #6
Arristillius
Got Wood.
 
Arristillius's Avatar
 
Join Date: 06-03-11
Location: Vancouver Wa
Downloads: 0
Uploads: 0
Default

Quote:
Originally Posted by Carbon View Post
Very nice build! I see your kettle is chained.
my neighborhood likes to run off with light and shiny things, the bps is heavy and hot atm so I didn't bother chaining it... I did buy a chain and lock though.

I am still debating on if I want the barrel sitting directly on my paver patio, or if I want a mat of some sort to protect it from grease, the cardboard under it right now is testing its heat output on the bottom, so far it hasn't even singed it. but I am noticing a lot of black drippings coming off the lid when I open it.
Arristillius is offline   Reply With Quote


Unread 04-30-2013, 09:05 PM   #7
mikemci
is one Smokin' Farker

 
mikemci's Avatar
 
Join Date: 04-19-13
Location: Live Oak, Texas
Downloads: 0
Uploads: 0
Default

You need to shoot your scumbag neighbor. Looks like a good job to me!
mikemci is offline   Reply With Quote


Unread 04-30-2013, 10:18 PM   #8
cowgirl
somebody shut me the fark up.

 
cowgirl's Avatar
 
Join Date: 07-18-07
Location: Oklahoma
Downloads: 0
Uploads: 0
Default

Great job on your build!
__________________
jeanie
sittin' by the campfire with my Brethren friends.
Lifetime member of the Society for the Preservation of Authentic Royal Magical Rare Kaskaskian Peppers (Thanks Ash :))

http://cowgirlscountry.blogspot.com/
cowgirl is online now   Reply With Quote


Unread 05-01-2013, 10:46 AM   #9
Arristillius
Got Wood.
 
Arristillius's Avatar
 
Join Date: 06-03-11
Location: Vancouver Wa
Downloads: 0
Uploads: 0
Default Results and Question

Almost forgot to grab some pics of the results, first couple people were loading up their plates by the time I remembered

here is a shot of the ribs, I cooked them to three donenesses, first one was taken off when it cracked as I bent it, then one rack was taken off every half hour after that, my guests liked the third rack that fell off the bone the best, I liked the second rack that almost fell off the bone, this pic is from the first rack.



and here is the fattys all sliced up, one of them was gobbled up in the slicing process by guests risking knife for meat.

the food was great, and nobody even reached for the bbq sauce I had on the table, so I consider it a successful cook

the one thing that concerned me a bit, was my lid was dripping nasty black slightly greasy water, whenever I opened it I had to be careful to go slow and angle it to run the grease into the barrel and away from the food.

and then near the end of the cook it stopped dripping and started flaking, looking like this.



so I guess my question is, what is the flaking and should I worry about it? the lid was stripped to bare metal, and then wiped down with peanut oil, assembled and heated to 250 for 10 hours, so I think it was seasoned properly, and until this cook had a shiny black appearance, this stuff is flaking away to leave a shiny black underneath it. so I don't think it's paint, I wonder if this has something to do with the dripping?
Arristillius is offline   Reply With Quote


Unread 05-01-2013, 10:52 AM   #10
Smoothsmoke
Babbling Farker

 
Join Date: 01-20-10
Location: Monterey, CA
Downloads: 0
Uploads: 0
Default

Get that crud off with a putty knife. If it's too hard, hit it with some oven cleaner, should come right off.

Your food looks great, and love the BPS drum.
__________________
Kamado Big Joe
Kamado Classic Joe
Kamado Joe Jr.

A bunch of Webers
Smoothsmoke is offline   Reply With Quote


Unread 05-01-2013, 12:19 PM   #11
Johnny_Crunch
Babbling Farker

 
Join Date: 04-03-10
Location: Cypress TX
Downloads: 0
Uploads: 0
Default

Nice pr0n!
__________________
J Crunch
Johnny_Crunch is offline   Reply With Quote


Unread 05-01-2013, 12:37 PM   #12
teej
On the road to being a farker
 
Join Date: 02-29-12
Location: Chatsworth, GA
Downloads: 0
Uploads: 0
Default

The flaking crud is just grease build up. Nothing to worry about, just scrub it off. I get it on my Akorn after nearly every cook.
teej is offline   Reply With Quote


Unread 05-01-2013, 12:44 PM   #13
oifmarine2003
is Blowin Smoke!

 
oifmarine2003's Avatar
 
Join Date: 11-26-12
Location: Grayslake, IL
Downloads: 0
Uploads: 0
Default

Quote:
Originally Posted by Arristillius View Post
my neighborhood likes to run off with light and shiny things.
Great job on the build. Your food looks outstanding. Now to build something to deal with that neighbor.......
__________________
Chris

Homemade Wood Smokehouse, Charmglow gasser, Smoke Hollow, UDS, dual chamber homemade grill, Uline Weber Kettle
Certified MOINK Baller

UNLINED DRUM KING OF CHICAGO AREA

Scrap Iron Chef
oifmarine2003 is offline   Reply With Quote


Unread 05-01-2013, 01:46 PM   #14
criffaaa1
is one Smokin' Farker

 
criffaaa1's Avatar
 
Join Date: 08-14-11
Location: Cleveland OH.
Downloads: 0
Uploads: 0
Default

everything looks great, and the bps kit is nice. I think that flaking stuff is creosote build up, that usually happens after many many cooks. the dripping was the creosote and condensation from the naturally most environment of the uds combining. so get rid of the flaky stuff and you should be good to go.
__________________
22.5 ots, 22.5 wsm, kingsford deluxe
criffaaa1 is offline   Reply With Quote


Unread 05-01-2013, 02:02 PM   #15
aawa
Babbling Farker

 
aawa's Avatar
 
Join Date: 07-03-12
Location: Virginia Beach
Downloads: 0
Uploads: 0
Default

Great looking UDS and food! I'm suprised they haven't ran off with your kettle, they can just remove the legs and run off with the kettle itself
__________________
*Weber Mini WSM* *Weber Touch and Go Performer X3* *Sublime Smoke UDS* *Maverick ET-732 * World's Fastest Blue Thermapen **Pitmaster IQ110*
aawa is online now   Reply With Quote


Reply

Thread Tools

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Loading



All times are GMT -5. The time now is 04:54 PM.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2014, vBulletin Solutions, Inc.
vBulletin Optimisation provided by vB Optimise v2.6.0 Beta 4 (Lite) - vBulletin Mods & Addons Copyright © 2014 DragonByte Technologies Ltd.
2003 -2012 © BBQ-Brethren Inc. All rights reserved. All Content and Flaming Pig Logo are registered and protected under U.S and International Copyright and Trademarks. Content Within this Website Is Property of BBQ Brethren Inc. Reproduction or alteration is strictly prohibited.
no new posts