The BBQ BRETHREN FORUMS.


Forum Portal Recipes Smoke Signals Magazine Welocme Merchandise Associations Purchase Subscription Brethren Banners
Go Back   The BBQ BRETHREN FORUMS. > Discussion Area > Catering, Food Handling and Awareness

Notices

Catering, Food Handling and Awareness *OnTopic* Forum to educate us on safe food handling. Not specifically for Catering or competition but overall health and keeping our families safe too.


Reply
Thread Tools
Unread 09-19-2012, 06:04 PM   #1
mjljr13
Is lookin for wood to cook with.
 
Join Date: 07-18-11
Location: moore sc
Downloads: 0
Uploads: 0
Default catering for 200+

In a little over two weeks I've been asked to provided: pp beans slaw potato salad rolls buns and tea. Of course I will be cooking my pulled pork this weekend pulling it then vacuum seal it. My questions are: should I just throw the pp thats in the vaccum packs into boiling water to heat it all. (Getting there early to do so) :beans I'm going to buy #10 cans of beans and Dr them up a bit will the best way to do this and heat them up be put them in a turkey fryer pot and warm them up then put in my warming pans?? : how early should I get there to start this im cooking 125lbs of raw pork 10 #10 cans of beans Im ok on the slaw potato salad tea. Just needing some advice on the other. Thanks brethren!
mjljr13 is offline   Reply With Quote


Unread 09-19-2012, 06:56 PM   #2
nthole
Babbling Farker

 
nthole's Avatar
 
Join Date: 08-11-03
Location: St. Louis
Downloads: 0
Uploads: 0
Default

You're cooking 100 pounds of beans for 200 people with two other sides available? That's 1/2 lb of cooked beans per person! It's gonna stink in there!!!

I'm thinking you may be over doing the beans. I'm not a catering expert though. Hopefully someone will chime in.
__________________
Neil -- "Easy Bake Master"
NB Bandera [gone to heaven...conveniently located in Long Island, NY]
Rebel 23, WSM A, WSM B, UDS, Easy Bake Oven
Pork Pistols BBQ
MOFO Illuminati

MOINK...It's what's for linner.
nthole is offline   Reply With Quote


Unread 09-19-2012, 07:06 PM   #3
chad
somebody shut me the fark up.
 
chad's Avatar
 
Join Date: 08-13-03
Location: Clearwater, FL
Downloads: 0
Uploads: 0
Default

#10 can is about 22-26 1/4 cup portions - depends on brand. So, I'd do about 8-9 cans.
125# of raw pork but should leave some overrun.

How early you get there depends on a number of things: how big is your cooker? What's the outside temp? How cold is the meat when you put it in the cooker? What time/temp profile do you usually use?

I just did pork for about 300+ last Sunday. I did 202# weighed pounds of raw pork. We fed everyone, sold about 10-12 quarts, and froze another 8 quarts for them to sell on Wednesday night. I cook hot so I started fire in the stickburner at 2:00 AM. Loaded at about 2:45 AM, took out of cooker at about 8:30 or so and let rest until about 10:00 AM when the first couple of pans were pulled.
__________________
Dave
Southern Brethren BBQ Competition Team

"It's all about getting paid!" - Myron Mixon
"I love being hated in my hometown!" - David Hair
KingFisher Gator Rotisserie cooker, WSM, Stainless 5 burner with IR gas grill, Turkey Fryer, Weber JD Commemorative grill, slightly used Bandera chamber for future use as a cold smoker, Masterbuilt 40" insulated ELECTRIC smoker
chad is offline   Reply With Quote


Unread 09-19-2012, 07:26 PM   #4
mjljr13
Is lookin for wood to cook with.
 
Join Date: 07-18-11
Location: moore sc
Downloads: 0
Uploads: 0
Default

# 10 can of beans weighs around 6 lbs or so....I'm actually going to pre cook the meat this weekend so I wont be rushing to get it all done that day....
mjljr13 is offline   Reply With Quote


Unread 10-19-2012, 01:03 PM   #5
Pigs on Fire
Full Fledged Farker
 
Join Date: 08-20-10
Location: Marietta, GA
Downloads: 0
Uploads: 0
Default

I don't mean to come off the wrong way, but from the sound of your post, you are not prepared to cook and coordinate a meal for 200 people.

Here's my other thoughts:

1. I'm glad I'm not paying you for this nor eating it. Sorry, but I do not condone pre-cooking, bagging and re-heating pulled pork...just because you don't think you have time to do it on serving day. Tough squat. Man up and do it right.

2. That's way too much baked beans. "Doctoring them up" is a wise suggestion. I do that and receive the "these are the best baked beans I've ever had" compliments. For 200 people, I would prepare 7, maybe 8 half-size pans. You really need to analyze the ages of the attendees and go from there. More kids (3-9) and older folks (55+), I might even consider 6 pans.

3. 125 lbs of raw butts is going to be about right for the amount of finished pork. That should be about 12 whole butts. I would certainly allow for ample cooking time and hold them in coolers/cambro. I pick most, if not all, of the fat out of one when I make pulled pork. This takes about 10 minutes per butt. Yes, that is roughly 2 man-hours for this project. Get some help. You better have help anyway for 200 people. Pull the pork, put it in 1/2 size pans, squirt some 50/50 apple juice and cider vinegar on it, cover with HD foil and either put back in the cambro or 200F oven to keep hot.

4. I would have the equivalent of 6 half-pans of potato salad. Probably 2-3 pans of cole slaw. I don't know, I don't prepare or serve or eat it, so I don't care. I've NEVER had anyone demand it (client) or ask for it (guest).

5. As far as cooking the beans, heat them in a 250F oven for 2+ hours.

6. I would buy about 160 buns (4") and only put out 30-40 initially and just put out a dozen at a time.

I hope you have chaffing dish racks...it sounds like you don't. I would get some, along with full size pans and sterno. Put the sterno under them, put 1" of water in the full size pans and put your beans and pork over the water.

I also set up my serving tables so that a line can go down each side of the table. I will usually have 2 complete tables set up, serving 4 lines at one time. I can get 175 people to fix their plate in less than 20 minutes. It is intense, but you need at least 2 people watching the lines at all times, getting refills ready. Sauce needs to be in bottles at the end, along with knives, forks, spoons and napkins. Don't make people pick all that crap up in the beginning and hang on to it. Have only plates and buns at the start.

Drinks are either at the end or on a separate table.

Me and my wife recently did a wedding like this for 175 people. We had pulled pork, ribs, beans, potato salad, broccoli slaw, some asian pasta salad she made, buns, a few burgers, and some grilled chicken for a few special diets. We worked 2 14-hour days to pull this off. Just me and her. We made every single thing we served from scratch (well I did dump beans out of a can.) Other than that, it was peeling 70# of taters, boiling 3 dozen eggs, etc. Trim, inject and rub 8 butts, 6 racks of ribs, patty burgers, trim chicken, etc. Mix sauce, bottle it, etc.

Lot of hard work, little sleep but to have nearly 150 people come up to you after it was over and say that it was the best food they've ever had was worth it.

Good luck.
Pigs on Fire is offline   Reply With Quote


Unread 11-07-2012, 02:13 PM   #6
vexter1
On the road to being a farker
 
vexter1's Avatar
 
Join Date: 10-24-07
Location: St. Louis, MO
Downloads: 0
Uploads: 0
Default

Well said - I concur with you on your thoughts. We do the same things and there is NOTHING like having people come up and let you know you rocked it. The hard work does pay off no doubt!

Quote:
Originally Posted by Pigs on Fire View Post
I don't mean to come off the wrong way, but from the sound of your post, you are not prepared to cook and coordinate a meal for 200 people.

Here's my other thoughts:

1. I'm glad I'm not paying you for this nor eating it. Sorry, but I do not condone pre-cooking, bagging and re-heating pulled pork...just because you don't think you have time to do it on serving day. Tough squat. Man up and do it right.

2. That's way too much baked beans. "Doctoring them up" is a wise suggestion. I do that and receive the "these are the best baked beans I've ever had" compliments. For 200 people, I would prepare 7, maybe 8 half-size pans. You really need to analyze the ages of the attendees and go from there. More kids (3-9) and older folks (55+), I might even consider 6 pans.

3. 125 lbs of raw butts is going to be about right for the amount of finished pork. That should be about 12 whole butts. I would certainly allow for ample cooking time and hold them in coolers/cambro. I pick most, if not all, of the fat out of one when I make pulled pork. This takes about 10 minutes per butt. Yes, that is roughly 2 man-hours for this project. Get some help. You better have help anyway for 200 people. Pull the pork, put it in 1/2 size pans, squirt some 50/50 apple juice and cider vinegar on it, cover with HD foil and either put back in the cambro or 200F oven to keep hot.

4. I would have the equivalent of 6 half-pans of potato salad. Probably 2-3 pans of cole slaw. I don't know, I don't prepare or serve or eat it, so I don't care. I've NEVER had anyone demand it (client) or ask for it (guest).

5. As far as cooking the beans, heat them in a 250F oven for 2+ hours.

6. I would buy about 160 buns (4") and only put out 30-40 initially and just put out a dozen at a time.

I hope you have chaffing dish racks...it sounds like you don't. I would get some, along with full size pans and sterno. Put the sterno under them, put 1" of water in the full size pans and put your beans and pork over the water.

I also set up my serving tables so that a line can go down each side of the table. I will usually have 2 complete tables set up, serving 4 lines at one time. I can get 175 people to fix their plate in less than 20 minutes. It is intense, but you need at least 2 people watching the lines at all times, getting refills ready. Sauce needs to be in bottles at the end, along with knives, forks, spoons and napkins. Don't make people pick all that crap up in the beginning and hang on to it. Have only plates and buns at the start.

Drinks are either at the end or on a separate table.

Me and my wife recently did a wedding like this for 175 people. We had pulled pork, ribs, beans, potato salad, broccoli slaw, some asian pasta salad she made, buns, a few burgers, and some grilled chicken for a few special diets. We worked 2 14-hour days to pull this off. Just me and her. We made every single thing we served from scratch (well I did dump beans out of a can.) Other than that, it was peeling 70# of taters, boiling 3 dozen eggs, etc. Trim, inject and rub 8 butts, 6 racks of ribs, patty burgers, trim chicken, etc. Mix sauce, bottle it, etc.

Lot of hard work, little sleep but to have nearly 150 people come up to you after it was over and say that it was the best food they've ever had was worth it.

Good luck.
vexter1 is offline   Reply With Quote


Reply

Thread Tools

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Loading



All times are GMT -5. The time now is 11:15 PM.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2014, vBulletin Solutions, Inc.
vBulletin Optimisation provided by vB Optimise v2.6.0 Beta 4 (Lite) - vBulletin Mods & Addons Copyright © 2014 DragonByte Technologies Ltd.
2003 -2012 © BBQ-Brethren Inc. All rights reserved. All Content and Flaming Pig Logo are registered and protected under U.S and International Copyright and Trademarks. Content Within this Website Is Property of BBQ Brethren Inc. Reproduction or alteration is strictly prohibited.
no new posts